60,000 Mile Service:

Engine / Under Hood

• Change engine oil & oil filter
• Replace engine air filter as required
• Replace cabin air filter as required
• Replace spark plugs
• Check ignition coils/boots and replace if necessary
• Replace serpentine/accessory drive belt
• Inspect tensioner & pulleys
• Inspect cooling-system hoses
• Check coolant level & condition
• Inspect radiator & cooling system for leaks
• Inspect water pump for leakage/noise
• Check brake fluid level & condition
• Check power-steering fluid, if applicable
• Check transmission fluid level/condition where serviceable
• Check windshield washer fluid
• Inspect engine/transmission for fluid leaks

Battery / Electrical

• Test battery condition
• Test charging system
• Inspect battery terminals & cables
• Inspect battery hold-down
• Check starter operation

Brakes

• Inspect front brake pads & rotors
• Inspect rear brake pads/shoes & rotors/drums
• Record brake pad thickness
• Inspect rotors for excessive wear/scoring
• Inspect brake calipers
• Inspect brake hoses & hard lines
• Check brake fluid lines for leaks
• Replace brake fluid 
• Inspect parking brake operation

Tires / Wheels

• Measure & record all tire tread depths
• Check tire pressures
• Inspect tires for cracking, damage & uneven wear
• Rotate tires if appropriate
• Inspect wheels for damage
• Check wheel/lug-nut condition
• Inspect spare tire/inflator kit
• Check alignment based on tire wear/road test

Steering / Suspension

• Inspect shocks & struts
• Inspect ball joints
• Inspect inner & outer tie rods
• Inspect control arms
• Inspect suspension bushings
• Inspect sway-bar links & bushings
• Inspect wheel bearings
• Check steering for excessive play
• Inspect power-steering system for leaks, if applicable

Transmission / Drivetrain

• Inspect transmission for leaks
• Check transmission fluid condition where applicable
• Service transmission fluid
• Inspect CV axles & CV boots
• Inspect driveshaft & U-joints where applicable
• Inspect differential(s) for leaks
• Check differential fluid/service interval
• Inspect transfer case on AWD/4WD vehicles
• Change transfer-case fluid/service interval

Cooling System

• Inspect radiator
• Complete Engine Coolant flush
• Inspect coolant reservoir
• Inspect upper & lower radiator hoses
• Inspect heater hoses
• Inspect thermostat operation
• Inspect cooling fans
• Check coolant freeze protection/condition
• Perform coolant service if required by manufacturer

Fuel / Emissions

• Inspect fuel lines & connections
• Check fuel filter replacement interval
• Inspect EVAP system for visible damage
• Check exhaust system
• Inspect catalytic converter
• Inspect exhaust hangers & heat shields
• Check for exhaust leaks

Exterior / Safety

• Check headlights
• Check high beams
• Check brake lights
• Check turn signals
• Check reverse lights
• Check hazard lights
• Check license-plate lights
• Check fog lights, if equipped
• Check horn
• Inspect windshield
• Inspect mirrors
• Inspect/replace wiper blades as needed
• Check windshield washers

Interior / HVAC

• Check A/C operation
• Check heater operation
• Check front/rear defrosters
• Check blower motor operation
• Check power windows
• Check power locks
• Check seat belts
• Check gauges & warning indicators

Computer / Diagnostic Inspection

• Scan all available modules for trouble codes
• Check for current, pending & stored codes
• Check maintenance/service reminders
• Reset maintenance reminder after service
• Verify no warning lights remain after service

Road Test

• Verify engine performance
• Verify transmission shifting/operation
• Check braking performance
• Check steering response
• Check suspension for noises
• Check wheel-bearing noise
• Check drivetrain vibration
• Check vehicle tracking/alignment
• Check acceleration
• Verify HVAC operation
• Verify no warning lights after road test